Yamaha YXR660FAS Service Manual Page 126
- Page / 421
- Table of contents
- TROUBLESHOOTING
- BOOKMARKS
Rated. / 5. Based on customer reviews
3 - 49
CHK
ADJ
CHECKING AND CHARGING THE BATTERY/
CHECKING THE FUSES
7. Install:
• battery
8. Connect:
• battery leads
CAUTION:
_
First, connect the positive battery lead
1
,
and then the negative battery lead
2
.
9. Check:
• battery terminals
Dirt → Clean with a wire brush.
Loose connection → Connect properly.
10.Lubricate:
• battery terminals
11.Install:
• battery case cover
12.Close the hood.
CHECKING THE FUSES
CAUTION:
Always turn off the main switch when
checking or replacing a fuse. Otherwise, a
short circuit may occur.
1. Lift the hood up.
2. Remove:
• battery case cover
3. Check:
• fuses
▼▼▼▼ ▼ ▼▼▼▼ ▼ ▼▼▼▼ ▼ ▼▼▼▼ ▼ ▼▼▼▼ ▼ ▼▼▼▼ ▼▼▼
a. Connect the pocket tester to the fuse and
check it for continuity.
NOTE:
Set the tester to the “Ω × 1” position.
b. If the tester indicates “∞”, replace the fuse.
▲▲▲▲ ▲ ▲▲▲▲ ▲ ▲▲▲▲ ▲ ▲▲▲▲ ▲ ▲▲▲▲ ▲ ▲▲▲▲ ▲▲▲
Recommended lubricant
Dielectric grease
Pocket tester
P/N. YU-03112-C, 90890-03112
- YXR660FAS 1
- EBS00001 2
- HOW TO USE THIS MANUAL 4
- EBS00006 5
- TABLE OF CONTENTS 7
- CONTENTS 8
- CHAPTER 1 8
- CHAPTER 2 8
- SPECIFICATIONS 8
- CHAPTER 3 9
- CHAPTER 4 10
- CHAPTER 8 14
- CHAPTER 9 15
- CHAPTER 10 17
- TROUBLESHOOTING 17
- GENERAL INFORMATION 18
- FEATURES 19
- IMPORTANT INFORMATION 22
- CHECKING OF CONNECTIONS 24
- SPECIAL TOOLS 25
- SAE 5W30 30
- GENERAL SPECIFICATIONS 31
- ENGINE SPECIFICATIONS 33
- (2.5°/0.055 in) 35
- (2.5°/0.063 in) 35
- CHASSIS SPECIFICATIONS 41
- ELECTRICAL SPECIFICATIONS 43
- TIGHTENING TORQUES 45
- EBS00022 51
- EBS00023 51
- EBS00024 52
- COOLANT FLOW DIAGRAMS 53
- OIL FLOW DIAGRAMS 56
- CABLE ROUTING 61
- INTRODUCTION 78
- INTRODUCTION/ 78
- ADJUSTING THE VALVE CLEARANCE 80
- ADJUSTING THE TIMING CHAIN/ 83
- ADJUSTING THE IDLING SPEED 83
- ADJUSTING THE IDLING SPEED/ 84
- ADJUSTING THE THROTTLE CABLE 84
- ADJUSTING THE THROTTLE CABLE/ 85
- ADJUSTING THE STARTER CABLE 85
- 18 Nm (1.8 m 86
- CHECKING THE IGNITION TIMING 87
- CHECKING THE IGNITION TIMING/ 88
- CHECKING THE ENGINE OIL LEVEL 90
- CHANGING THE ENGINE OIL 91
- 30 Nm (3.0 m 92
- CHANGING THE ENGINE OIL/ 93
- CLEANING THE AIR FILTER 93
- CLEANING THE AIR FILTER/ 95
- CHECKING THE COOLANT LEVEL 95
- CHECKING THE COOLANT LEVEL/ 96
- CHANGING THE COOLANT 96
- LIGHT/CHECKING THE V-BELT 100
- CHECKING THE V-BELT 101
- CHECKING THE V-BELT/ 102
- CLEANING THE SPARK ARRESTER 102
- ADJUSTING THE BRAKE PEDAL 103
- ADJUSTING THE PARKING BRAKE 104
- 4 Reverse 109
- 5 Select lever shift rod 109
- 1 Neutral 109
- 23 Nm (2.3 m 110
- CHANGING THE FINAL GEAR OIL/ 111
- CHECKING THE STEERING SYSTEM/ 114
- ADJUSTING THE TOE-IN 114
- Rawhide 117
- CHECKING THE TIRES 118
- CHECKING THE WHEELS/ 119
- LUBRICATING THE PEDAL, ETC 120
- ELECTRICAL 121
- Open-circuit voltage (V) 122
- CAUTION: 125
- CHECKING THE FUSES 126
- ADJUSTING THE HEADLIGHT BEAM/ 128
- CHANGING THE HEADLIGHT BULB 128
- CHANGING THE HEADLIGHT BULB/ 129
- 7 Nm (0.7 m 130
- ENGINE REMOVAL 131
- 10 Nm (1.0 m 134
- CYLINDER HEAD COVER 139
- ROCKER ARMS 143
- CAMSHAFT AND CYLINDER HEAD 147
- VALVES AND VALVE SPRINGS 155
- CYLINDER AND PISTON 163
- Order Job/Part Q’ty Remarks 172
- 18 Starter idle gear 1 172
- PRIMARY AND SECONDARY SHEAVES 182
- CRANKCASE 196
- CRANKSHAFT AND OIL PUMP 203
- TRANSMISSION 209
- MIDDLE GEAR 215
- COOLING SYSTEM 229
- 11 Coolant reservoir 1 230
- WATER PUMP 234
- OIL COOLER 238
- FUEL SYSTEM 241
- FUEL PUMP AND FUEL TANK 242
- CARBURETOR 244
- DRIVE TRAIN 252
- GEAR AND DRIVE SHAFT 255
- DRIVE SHAFT 255
- 13 Passenger seat support 1 291
- FRONT WHEELS AND BRAKE DISCS 296
- REAR WHEELS AND BRAKE DISC 300
- FRONT AND REAR BRAKES 304
- 9 Nm (0.9 m 311
- 16 Nm (1.6 m 329
- PEDAL ASSEMBLY 330
- STEERING SYSTEM 331
- 40 Nm (4.0 m 332
- 10 Circlip 1 343
- 11 Ball joint 1 343
- REAR KNUCKLE AND STABILIZER 348
- ELECTRICAL COMPONENTS 354
- CHECKING THE SWITCH 355
- CHECKING THE BULBS AND 358
- BULB SOCKETS 358
- IGNITION SYSTEM 361
- ELECTRIC STARTING SYSTEM 367
- CHARGING SYSTEM 375
- LIGHTING SYSTEM 378
- SIGNALING SYSTEM 384
- 2WD/4WD SELECTING SYSTEM 403
- CARBURETOR HEATING SYSTEM 408
- POOR IDLE SPEED PERFORMANCE 413
- FAULTY DRIVE TRAIN 414
- FAULTY GEAR SHIFTING/ 415
- FAULTY CLUTCH PERFORMANCE 415
- FAULTY GEAR SHIFTING 415
- OVERHEATING 416
- FAULTY BRAKE 416
- SHOCK ABSORBER MALFUNCTION 416
- UNSTABLE HANDLING/ 417
- UNSTABLE HANDLING 417
- PRINTED IN U.S.A 420
Related products and manuals for Toys & accessories Yamaha YXR660FAS
Toys & accessories Yamaha YZF-R1 Service Manual
(439 pages)
(439 pages)
Toys & accessories Yamaha YZF-R1 User Manual
(21 pages)
(21 pages)
(6 pages)
(3 pages)© 2020, manymanuals.com. All rights reserved. | 0.398 s |
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Comments to this Manuals