Yamaha TZ125M1 Service Manual Page 56
- Page / 257
- Table of contents
- BOOKMARKS
Rated. / 5. Based on customer reviews
ENGINE/COOLING WATER LEVEL INSPECTION/
COOLING WATER REPLACEMENT
3-6
EC350011
ENGINE
CC
CAUTION:
• The cooling system is filled with coolant at
the factory to prevent rusting. Be sure to
replace coolant with soft water before rid-
ing.
• Take care so that coolant does not splash
on painted surfaces. If it splashes, wash it
away with water.
EC352000
COOLING WATER LEVEL INSPECTION
W
Do not remove the radiator cap
11
, drain
bolt and hoses when the engine and radia-
tor are hot. Scalding hot fluid and steam
may be blown out under pressure, which
could cause serious injury.
When the engine has cooled, place a thick
towel over the radiator cap, slowly rotate
the cap counterclockwise to the detent.
This procedure allows any residual pres-
sure to escape. When the hissing sound
has stopped, press down on the cap while
turning counterclockwise and remove it.
CC
CAUTION:
Hard water or salt water is harmful to the
engine parts. You may use distilled water, if
you can’t get soft water.
1. Place the machine on a level place, and
hold it in an upright position.
2. Remove:
• Radiator cap
3. Check:
• Cooling water level a
Cooling water level low -› Add cooling
water.
1 Radiator
INSP
ADJ
EC354002
COOLING WATER REPLACEMENT
W
Do not remove the radiator cap when the
engine is hot.
1. Remove the lower cowl.
2. Place a container under the radiator hose.
- TZ125M1/(M) 1
- EC010000 2
- INTRODUCTION 3
- WARRANTY INFORMATION 4
- IMPORTANT NOTICE 5
- TO THE NEW OWNER 7
- F.I.M. MACHINE WEIGHTS: 7
- HOW TO USE 8
- THIS MANUAL 8
- MANUAL FORMAT 9
- HOW TO READ DESCRIPTIONS 9
- ILLUSTRATED SYMBOLS 10
- (Refer to the illustration) 10
- EC090000 12
- CONTENTS 13
- GENERAL INFORMATION 15
- MACHINE IDENTIFICATION 16
- IMPORTANT INFORMATION 17
- CHECKING OF CONNECTION 19
- SPECIAL TOOLS 20
- CONTROL FUNCTIONS 23
- FUEL AND ENGINE MIXING OIL 28
- INFORMATION BEFORE PRE 29
- OPERATION 29
- STARTING AND BREAK-IN 30
- TORQUE-CHECK POINTS 33
- CLEANING AND STORAGE 34
- SPECIFICATIONS 36
- GENERAL SPECIFICATIONS 37
- MAINTENANCE SPECIFICATIONS 38
- – 6 2 0.2 1.4 40
- DEFINITION OF UNITS 46
- GENERAL TORQUE SPECIFICATIONS 46
- CABLE ROUTING DIAGRAM 47
- MAINTENANCE INTERVALS 51
- EC320010 54
- EC321010 54
- EC340000 55
- COOLING WATER REPLACEMENT 56
- COOLING SYSTEM INSPECTION 58
- THROTTLE CABLE ADJUSTMENT 59
- TRANSMISSION OIL LEVEL CHECK 60
- PILOT AIR SCREW ADJUSTMENT/ 62
- EC360000 63
- EC361002 63
- FRONT BRAKE ADJUSTMENT/ 64
- REAR BRAKE ADJUSTMENT 64
- EC366031 66
- BRAKE FLUID LEVEL INSPECTION/ 68
- SPROCKETS INSPECTION 68
- DRIVE CHAIN INSPECTION 69
- DRIVE CHAIN SLACK ADJUSTMENT 70
- WHEEL ALIGNMENT ADJUSTMENT 72
- FRONT FORK INSPECTION/ 73
- FRONT FORK TOP END ADJUSTMENT 73
- ADJUSTMENT 76
- SEAT HEIGHT ADJUSTMENT 78
- FORCE ADJUSTMENT 80
- WHEEL INSPECTION 82
- EC36U060 83
- STEERING DAMPER ADJUSTMENT 84
- WIRES, CABLES/ 85
- LUBRICATION 86
- IGNITION TIMING CHECK 88
- COWLING, SEAT AND FUEL TANK 89
- EXHAUST PIPE AND SILENCER 91
- RADIATOR 92
- 1 Nm (0.1 mdkg, 0.7 ftdlb) 100
- 11 Nm (1.1 mdkg, 8.0 ftdlb) 100
- CARBURETOR AND REED VALVE 101
- 2 Nm (0.2 mdkg, 1.4 ftdlb) 104
- CYLINDER HEAD AND CYLINDER 105
- 15 Nm (1.5 mdkg, 11 ftdlb) 106
- CAUTION: 107
- EC474520 111
- EC474720 111
- EC475000 112
- EC475261 112
- 20 Nm (2.0 mdkg, 14 ftdlb) 113
- 19 Nm (1.9 mdkg, 13 ftdlb) 114
- 6 Nm (0.6 mdkg, 4.3 ftdlb) 115
- 50 Nm (5.0 mdkg, 36 ftdlb) 116
- EC484500 118
- EC484600 118
- EC4A4200 118
- EC4A4300 118
- AND BALANCER SHAFT 123
- 55 Nm (5.5 mdkg, 40 ftdlb) 128
- SHIFT SHAFT AND OIL PUMP 130
- 4 Nm (0.4 mdkg, 2.9 ftdlb) 133
- 7 Nm (0.7 mdkg, 5.1 ftdlb) 134
- 22 Nm (2.2 mdkg, 16 ftdlb) 135
- 14 Nm (1.4 mdkg, 10 ftdlb) 135
- 8 Nm (0.8 mdkg, 5.8 ftdlb) 136
- 60 Nm (6.0 mdkg, 43 ftdlb) 136
- EC4H3000 138
- EC4F3100 138
- EC4H3100 138
- EC4H3210 138
- EC4H3300 139
- EC4H4000 139
- EC4H4100 139
- EC4H4210 139
- EC4H4300 140
- EC4H4600 140
- EC4H4701 140
- CDI MAGNETO 146
- 53 Nm (5.3 mdkg, 38 ftdlb) 148
- ENGINE REMOVAL 149
- 30 Nm (3.0 mdkg, 22 ftdlb) 152
- 16 Nm (1.6 mdkg, 11 ftdlb) 153
- 23 Nm (2.3 mdkg, 17 ftdlb) 153
- EC4N3401 156
- EC4Q3300 156
- EC4Q4000 156
- EC4N4101 156
- EC4N4201 157
- EC444200 157
- EC444400 157
- EC4Q5000 158
- EC4Q5101 158
- EC4Q5201 158
- FRONT WHEEL AND REAR WHEEL 162
- 48 Nm (4.8 mdkg, 35 ftdlb) 167
- 32 Nm (3.2 mdkg, 23 ftdlb) 168
- 63 Nm (6.3 mdkg, 45 ftdlb) 169
- FRONT BRAKE AND REAR BRAKE 170
- 35 Nm (3.5 mdkg, 25 ftdlb) 178
- 18 Nm (1.8 mdkg, 13 ftdlb) 178
- 5 Nm (0.5 mdkg, 3.6 ftdlb) 180
- 12 Nm (1.2 mdkg, 8.7 ftdlb) 182
- 26 Nm (2.6 mdkg, 19 ftdlb) 182
- 8Nm (0.8 mdkg,5.8 ftdlb) 184
- FRONT FORK 186
- 40 Nm (4.0 mdkg, 29 ftdlb) 192
- HANDLEBAR 200
- STEERING 205
- 80 Nm (8.0 mdkg, 58 ftdlb) 210
- SWINGARM 212
- 34 Nm (3.4 mdkg, 24 ftdlb) 216
- REAR SHOCK ABSORBER 219
- ELECTRICAL 225
- IGNITION SYSTEM 226
- SOLENOID VALVE SYSTEM 230
- THERMO UNIT SYSTEM 233
- EC700000 235
- EC710000 235
- EC711011 235
- EC712000 235
- EC714032 236
- EC71E011 236
- EC71S000 239
- EC71B030 240
- EC71H031 240
- Carburetor setting parts 242
- * Factory installed 242
- 3rd gear 246
- 4th gear 246
- 5th gear 246
- 6th gear 246
- Part name Size Part number 247
- EC720000 248
- EC72J001 248
- EC72M001 249
- EC72K014 250
- SETTING CHART 251
- ACTUAL RUN 251
- Driven sprocket 252
- Drive sprocket 252
- EC72L003 253
- Setting record table 255
- Setting specs: 255
- 99.8-0.1x1 257
Related products and manuals for Motorcycles Yamaha TZ125M1
Motorcycles Yamaha TEO'S XN125 Service Manual
(259 pages)
(259 pages)
Motorcycles Yamaha BT1100 2002 Service Manual
(356 pages)
(356 pages)
Motorcycles Yamaha TDM850 Owner's Manual
(110 pages)
(110 pages)
Motorcycles Yamaha YBR 125K Owner's Manual
(83 pages)
(83 pages)
Motorcycles Yamaha XTZ1200Z User Manual
(106 pages)
(106 pages)
Motorcycles Yamaha YZ85(S)/LC Service Manual
(506 pages)
(506 pages)
Motorcycles Yamaha R-700 Service Manual
(402 pages)
(402 pages)
Motorcycles Yamaha YP125R User Manual
(88 pages)
(88 pages)
Motorcycles Yamaha FZ6-NHG Owner's Manual
(98 pages)
(98 pages)
Motorcycles Yamaha FZ6-SA User Manual
(113 pages)
(113 pages)
Motorcycles Yamaha XT225V Installation Guide
(16 pages)
(16 pages)
Motorcycles Yamaha TT-R50EY User Manual
(76 pages)
(76 pages)
Motorcycles Yamaha DT125X Owner's Manual
(74 pages)
(74 pages)
Motorcycles Yamaha WR250F(T) User Manual
(32 pages)
(32 pages)
Motorcycles Yamaha XMAX YP250R User Manual
(88 pages)
(88 pages)
Motorcycles Yamaha YDP-135 Owner's Manual
(36 pages)
(36 pages)
© 2020, manymanuals.com. All rights reserved. | 0.050 s |
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Comments to this Manuals