Yamaha TDM850 Owner's Manual Page 85
- Page / 110
- Table of contents
- TROUBLESHOOTING
- BOOKMARKS
Rated. / 5. Based on customer reviews
PERIODIC MAINTENANCE AND MINOR REPAIR
6-40
6
3. Remove the brake caliper on each
side by removing the bolts.
ECA00046
CAUTION:
@
Do not apply the brake after the
brake calipers have been removed,
otherwise the brake pads will be
forced shut.
@
4. Pull the wheel axle out, and then
remove the wheel.
EAU03829
To install the front wheel
1. Lift the wheel up between the fork
legs.
2. Insert the wheel axle from the
right-hand side.
3. Lower the front wheel so that it is
on the ground.
4. Install the brake calipers by install-
ing the bolts.
NOTE:
_
Make sure that there is enough space
between the brake pads before install-
ing the brake calipers onto the brake
discs.
_
5. Tighten the wheel axle, the front
wheel axle pinch bolt and the
brake caliper bolts to the specified
torques.
6. Push down hard on the handlebar
several times to check for proper
fork operation.
1. Bolt (× 2)
2. Brake caliper
Tightening torques:
Wheel axle:
58 Nm (5.8 m·kg)
Front wheel axle pinch bolt:
19 Nm (1.9 m·kg)
Brake caliper bolt:
40 Nm (4.0 m·kg)
E_4tx.book Page 40 Wednesday, October 4, 2000 4:28 PM
- OWNER’S MANUAL 1
- INTRODUCTION 3
- IMPORTANT MANUAL INFORMATION 4
- TABLE OF CONTENTS 7
- GIVE SAFETY THE RIGHT OF WAY 10
- DESCRIPTION 11
- Main switch/steering lock 16
- Speedometer unit 18
- Tachometer 19
- Self-diagnosis device 19
- Anti-theft alarm (optional) 20
- Fuel gauge 20
- Handlebar switches 20
- 1. Engine stop switch 21
- 2. Light switch 21
- 3. Start switch “ ” 21
- Clutch lever 22
- Shift pedal 22
- Brake lever 22
- Brake pedal 23
- Fuel tank cap 24
- Fuel tank breather hose 25
- (for Germany only) 25
- Starter (choke) lever “ ” 25
- Helmet holder 26
- Storage compartment 27
- Adjusting the front fork 28
- EC000015 29
- Adjusting the shock absorber 30
- EC000018 31
- Luggage strap holders 32
- Sidestand 32
- EW000044 33
- EAU03720 33
- EW000045 33
- PRE-OPERATION CHECKS 35
- Starting the engine 40
- Starting a warm engine 41
- Shifting 42
- Recommended shift points 42
- (for Switzerland only) 42
- Tips for reducing fuel 43
- Engine break-in 43
- Parking 44
- Owner’s tool kit 46
- EAU03685 47
- EAU03541 49
- Removing and installing 50
- 1. Screw 51
- Checking the spark plugs 52
- Engine oil and oil filter 54
- Coolant 56
- EC000080 57
- EW000067 57
- 2. Radiator cap 58
- 2. Bolt (× 2) 59
- 3. Clamp 59
- 1. Bolt (× 3) 60
- 1. Air filter element 62
- Adjusting the carburetors 63
- Adjusting the engine idling 63
- Adjusting the throttle cable 64
- EWA00012 65
- EW000079 66
- EW000080 66
- EAU00684 67
- Adjusting the brake pedal 68
- 1. Brake light switch 69
- Checking the front and rear 70
- Changing the brake fluid 71
- Drive chain slack 72
- 2. Brake caliper bracket 73
- Lubricating the drive chain 74
- Checking and lubricating the 74
- Lubricating the rear 77
- Checking the front fork 77
- Checking the steering 78
- Checking the wheel bearings 78
- Battery 79
- Replacing the fuses 80
- Replacing a headlight bulb 81
- 2. Tail/brake light lens 82
- 2. Turn signal light lens 83
- 1. Turn signal light bulb 83
- Supporting the motorcycle 84
- Front wheel 84
- 1. Bolt (× 2) 85
- 2. Brake caliper 85
- Rear wheel 86
- 1. Locknut 87
- Troubleshooting 88
- Troubleshooting charts 89
- Have a Yamaha dealer check 90
- Yamaha dealer check 90
- MOTORCYCLE CARE AND STORAGE 91
- SPECIFICATIONS 100
- CONSUMER INFORMATION 103
Related products and manuals for Motorcycles Yamaha TDM850
Motorcycles Yamaha YBR 125K Owner's Manual
(83 pages)
(83 pages)
Motorcycles Yamaha XTZ1200Z User Manual
(106 pages)
(106 pages)
Motorcycles Yamaha YZ85(S)/LC Service Manual
(506 pages)
(506 pages)
Motorcycles Yamaha R-700 Service Manual
(402 pages)
(402 pages)
Motorcycles Yamaha YP125R User Manual
(88 pages)
(88 pages)
Motorcycles Yamaha FZ6-NHG Owner's Manual
(98 pages)
(98 pages)
Motorcycles Yamaha FZ6-SA User Manual
(113 pages)
(113 pages)
Motorcycles Yamaha XT225V Installation Guide
(16 pages)
(16 pages)
Motorcycles Yamaha TT-R50EY User Manual
(76 pages)
(76 pages)
Motorcycles Yamaha DT125X Owner's Manual
(74 pages)
(74 pages)
Motorcycles Yamaha WR250F(T) User Manual
(32 pages)
(32 pages)
Motorcycles Yamaha XMAX YP250R User Manual
(88 pages)
(88 pages)
Motorcycles Yamaha YDP-135 Owner's Manual
(36 pages)
(36 pages)
Motorcycles Yamaha SH50M User Manual
(27 pages)
(27 pages)
Motorcycles Yamaha FZ1-NA User Manual
(106 pages)
(106 pages)
Motorcycles Yamaha TDM900A Service Manual
(137 pages)
(137 pages)
Motorcycles Yamaha R1 User Manual
(8 pages)
(8 pages)
© 2020, manymanuals.com. All rights reserved. | 0.035 s |
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Comments to this Manuals