Yamaha MBK YQ100 Service Manual Page 14
- Page / 232
- Table of contents
- TROUBLESHOOTING
- BOOKMARKS
Rated. / 5. Based on customer reviews
GEN
INFO
1-6
SPECIAL TOOLS
Crankshaft installer pot
Crankshaft installer bolt
Adapter
Spacer
These tools are used to install the crank-
shaft.
Flywheel puller
This tool is used to remove the flywheel
magneto.
Rotor holding tool
This tool is used to remove the flywheel
magneto.
Crankcase separating tool
This tool is used to separate the crank-
case and remove the crankshaft.
90890-01135
90890-01189
90890-01235
90890-01274
90890-01275
90890-01277
90890-01288
90890-01701
90890-01348
Sheave holder
This tool is used to hold the secondary
sheave when removing or installing the
nut.
Locknut wrench
This tool is used when removing or
installing the secondary sheave nut.
Tool N° Tool name/usage Illustration
EAS00027
SPECIAL TOOLS
The following special tools are necessary for complete and accurate tune-up and assembly. Use
only the appropriate special tools as this will help prevent damage caused by the use of inappropriate
tools or improvised techniques. Special tools, part numbers or both may differ depending on the
country.
When placing an order, refer to the list provided below to avoid any mistakes.
Oil seal guide
This tool is used to protect the oil seal lip
when installing the secondary sheave.
90890-01384
90890-03079
Thickness gauge
This tool is used to measure the clearance.
- 5ME1-AE1 1
- CAUTION: 3
- HOW TO USE THIS MANUAL 4
- EAS00009 5
- EAS00011 6
- CHAPTER 1 8
- GENERAL INFORMATION 8
- IMPORTANT INFORMATION 10
- CHECKING THE CONNECTIONS 12
- SPECIAL TOOLS 14
- EAS00027 14
- CHAPTER 2 17
- SPECIFICATIONS 17
- GENERAL SPECIFICATIONS 19
- MAINTENANCE SPECIFICATIONS 21
- TIGHTENING TORQUES 24
- GENERAL TORQUE SPECIFICATIONS 31
- GENERAL TIGHTENING TORQUE 31
- EAS00031 32
- EAS00032 33
- CABLE ROUTING 34
- EAS00035 34
- CHAPTER 3 43
- Every 12,000 km 44
- Every 20,000 km 45
- 3 Nm (0,3 m.kg) 50
- 3 Nm (0,3m.kg) 50
- 4 Nm (0,4 m.kg) 52
- 322025(b) 54
- EAS00058 55
- CHECKING THE SPARK PLUG 56
- CHECKING THE ENGINE OIL LEVEL 58
- AUTOLUBE PUMP AIR BLEEDING 59
- AUTOLUBE PUMP AIR BLEEDING/ 60
- ADJUSTING THE FRONT BRAKE/ 62
- ADJUSTING THE REAR BRAKE 62
- EAS00116 63
- CHECKING THE BRAKE SHOES/ 64
- WARNING 65
- CHECKING THE FRONT FORK 67
- EAS00165 68
- CHECKING THE TIRES 68
- CHECKING THE WHEELS/ 70
- LUBRICATING THE CENTERSTAND/ 71
- CHECKING THE BATTERY 72
- ELECTRICAL SYSTEM 72
- CHECKING THE BATTERY/ 75
- CHECKING THE FUSE 75
- CHECKING THE FUSE/ 76
- REPLACING THE HEADLIGHT BULB 76
- REPLACING THE HEADLIGHT BULB/ 77
- ADJUSTING THE HEADLIGHT BEAM 77
- CHAPTER 4 79
- OVERHAULING THE ENGINE 79
- OVERHAULING THE ENGINE 81
- EAS00192 84
- CYLINDER HEAD 86
- EAS00222 86
- 52.002~52.012mm 89
- 52.10 mm 89
- SECONDARY SHEAVE 98
- V-BELT, CLUTCH AND 100
- SECONDARY/PRIMARY SHEAVE 100
- INSPECTION AND REPAIR 109
- C.D.I. MAGNETO 110
- ENGINE DISASSEMBLY 111
- AUTOLUBE PUMP 112
- TRANSMISSION 114
- EAS00423 116
- CRANKCASE AND REED VALVE 117
- CRANKSHAFT 122
- CHAPTER 5 126
- CARBURETOR 126
- EAS00480 127
- EAS000483 128
- EAS00487 131
- EAS00492 132
- FUEL COCK 133
- REED VALVE 134
- REED VALVE 134
- YP600051 135
- CHAPTER 6 137
- FRONT WHEEL AND BRAKE DISC 139
- EAS00513 139
- EAS00518 140
- EAS00520 141
- EAS00523 141
- EAS00525 142
- EAS00528 144
- 23 Nm (2,3 m.kg) 145
- EAS00548 147
- REAR WHEEL AND BRAKE 149
- EAS00555 149
- EAS00565 151
- EAS00569 151
- FRONT BRAKE 154
- EAS00576 154
- EAS00579 155
- EAS00584 157
- 1.2 Nm (0.12 m.kg) 158
- EAS00588 159
- EAS00590 159
- EAS00596 160
- EAS00612 162
- EAS00614 163
- EAS00631 165
- EAS00635 166
- EAS00646 168
- FRONT FORK 168
- EAS00654 170
- EAS00656 171
- EAS00659 172
- 60 Nm (6,0 m.kg) 175
- EAS00666 177
- EAS00668 177
- HANDLEBAR 177
- EAS00673 178
- STEERING HEAD 180
- EAS00675 180
- REAR SHOCK ABSORBER ASSEMBLY 184
- EAS00695 185
- CHAPTER 7 187
- ELECTRICAL 187
- CIRCUIT DIAGRAM 189
- ELECTRICAL COMPONENTS 190
- SWITCH INSPECTION 192
- A Starter switch 194
- IGNITION AND STARTING SYSTEM 195
- Ω (20°C) 196
- Ω at 20°C 197
- IGNITION AND STARTER SYSTEM 200
- STARTER MOTOR 201
- CHARGING SYSTEM 204
- LIGHTING SYSTEM 208
- 21W / 5W 213
- SIGNAL SYSTEM 215
- CHAPTER 8 224
- TROUBLESHOOTING 224
- POOR IDLE SPEED PERFORMANCE 226
- FAULTY AUTOMATIC 227
- FAULTY AUTOMATIC/ 228
- OVER HEATING 228
- IMPROPER KICKING/ 229
- FAULTY BRAKE 229
- IMPROPER KICKING 229
- YQ100 WIRING DIAGRAM 232
Related products and manuals for Scooters Yamaha MBK YQ100
Scooters Yamaha VINO 125 Service Manual
(294 pages)
(294 pages)
Scooters Yamaha VXR Operator's Manual
(28 pages)
(28 pages)
Scooters Yamaha BWS YW100E Owner's Manual
(63 pages)
(63 pages)
Scooters Yamaha YQ50/YQ50L Owner's Manual
(84 pages)
(84 pages)
Scooters Yamaha NEO'S YN50 Owner's Manual
(72 pages)
(72 pages)
Scooters Yamaha BWS CW50RS Owner's Manual
(80 pages)
(80 pages)
Scooters Yamaha SLIDER EW50 Owner's Manual
(80 pages)
(80 pages)
Scooters Yamaha AEROX YQ50 Owner's Manual
(68 pages)
(68 pages)
Scooters Yamaha YW125Z User Manual
(38 pages)
(38 pages)
Scooters Yamaha BWS CW50L Owner's Manual
(68 pages)
(68 pages)
Scooters Yamaha EC-03 Owner's Manual
(78 pages)
(78 pages)
Scooters Yamaha VXS User Manual
(6 pages)
(6 pages)
Scooters Yamaha MAJESTY YP180E User Manual
(28 pages)
(28 pages)
Scooters Yamaha CYGNUS RS XC125E User Manual
(13 pages)
(13 pages)
Scooters Yamaha Xenter HW151 User Manual
(1 pages)
(1 pages)
Scooters Yamaha MAJESTY YP180E User Manual
(57 pages)
Scooters Yamaha why YH50 Owner's Manual
(80 pages)
(80 pages)
© 2020, manymanuals.com. All rights reserved. | 0.759 s |
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Comments to this Manuals