Yamaha XJR1300SP Owner's Manual

5EA-28199-E2XJR1300XJR1300SPOWNER’S MANUAL

2DESCRIPTIONLeft view ... 2-1Right view...

2-12EAU000262-DESCRIPTIONLeft view1. Clutch fluid reservoir (page 6-18)2. Fuel cock (page 3-10)3. Rear shock absorber spring preload adjusting ring (p

DESCRIPTION2-22Right view8. Tail/brake light (page 6-27)9. Luggage strap holders (page 3-15)10. Tool kit (page 6-1)11. Rear brake fluid reservoir (pag

DESCRIPTION2-32Controls/Instruments1. Clutch lever (page 3-7)2. Left handlebar switches (page 3-5)3. Starter (choke) “ ” (page 3-11)4. Speedometer (pa

3INSTRUMENT AND CONTROL FUNCTIONSMain switch/steering lock...3-1Indicator lights ...

3-13EAU000273-INSTRUMENT AND CONTROL FUNCTIONSEAU00029*Main switch/steering lockThe main switch controls the ignitionand lighting systems. Its operati

INSTRUMENT AND CONTROL FUNCTIONS3-23EAU01590 (Parking)The steering is locked in this position,and the taillight and auxiliary light comeon but all oth

INSTRUMENT AND CONTROL FUNCTIONS3-33EAU00073Oil level indicator circuit checkCB-52EWait a few seconds (see NOTE).Oil level indicator light goes off.Oi

INSTRUMENT AND CONTROL FUNCTIONS3-43EAU00097SpeedometerThe speedometer shows riding speed.This speedometer is equipped with anodometer and trip odomet

INSTRUMENT AND CONTROL FUNCTIONS3-53EAU00110Fuel gaugeThis model is equipped with an electricfuel gauge so the rider can monitor thefuel level in the

EAU00001INTRODUCTIONWelcome to the Yamaha world of motorcycling!As the owner of a XJR1300/XJR1300SP, you are benefiting from Yamaha’s vastexperience i

INSTRUMENT AND CONTROL FUNCTIONS3-63EAU00138Engine stop switchThe engine stop switch is a safety de-vice for use in an emergency such aswhen the motor

INSTRUMENT AND CONTROL FUNCTIONS3-73EAU00153Clutch leverThe clutch lever is located on the lefthandlebar. It is equipped with a clutchlever adjusting

INSTRUMENT AND CONTROL FUNCTIONS3-83EAU00161Front brake leverThe front brake lever is located on theright handlebar and is equipped with abrake lever

INSTRUMENT AND CONTROL FUNCTIONS3-93EAU02935Fuel tank capTo openOpen the lock cover. Insert the key andturn it 1/4 turn clockwise. The lock willbe rel

INSTRUMENT AND CONTROL FUNCTIONS3-103EAU00185CAUTION:@ Always wipe off spilled fuel immedi-ately with a dry and clean soft cloth.Fuel may deteriorate

INSTRUMENT AND CONTROL FUNCTIONS3-113PRIThis stands for “prime”. If the enginehas been allowed to run out of fuel, turnthe lever to the “PRI” position

INSTRUMENT AND CONTROL FUNCTIONS3-123To installInsert the projection on the front of theseat into the holder, then push downthe seat.NOTE:@ Make sure

INSTRUMENT AND CONTROL FUNCTIONS3-133EAU00285Front fork adjustmentThis front fork is equipped with springpreload adjusting bolts.EW000037WARNING@ Each

INSTRUMENT AND CONTROL FUNCTIONS3-143To decrease spring preload, turn the ad-justing rings as shown in illustration .EW000040WARNING@ Always adjust ea

INSTRUMENT AND CONTROL FUNCTIONS3-153EAU00324Luggage strap holdersThere are four luggage strap holdersbelow the passenger seat, two of whichcan be tur

EAU00005IMPORTANT MANUAL INFORMATIONParticularly important information is distinguished in this manual by the following notations:The Safety Alert Sym

INSTRUMENT AND CONTROL FUNCTIONS3-163CD-08ESIDESTAND IS DOWN.ENGINE WILL STALL.SIDESTAND SWITCH IS OK.CLUTCH SWITCH IS OK.

4PRE-OPERATION CHECKSPre-operation check list... 4-1

4-14EAU011144-PRE-OPERATION CHECKSOwners are personally responsible for their vehicle’s condition. Your motorcycle’s vital functions can start to dete

PRE-OPERATION CHECKS4-24NOTE:Pre-operation checks should be made each time the motorcycle is used. Such an inspection can be thoroughly accom-plished

5OPERATION AND IMPORTANT RIDING POINTSStarting the engine... 5-1Starting a w

5-15EAU003725-OPERATION AND IMPORTANT RIDING POINTSEAU00373WARNING@ ● Before riding this motorcycle,become thoroughly familiarwith all operating contr

OPERATION AND IMPORTANT RIDING POINTS5-25CF-33ETURN THE MAIN SWITCH TO “ON” AND THE ENGINE STOP SWITCH TO “ ”.IF TRANSMISSION IS IN NEUTRAL AND SIDEST

OPERATION AND IMPORTANT RIDING POINTS5-351. Turn the fuel cock to “ON”.2. Turn the main switch to “ON” andthe engine stop switch to “ ”.3. Shift trans

IMPORTANT MANUAL INFORMATIONEW000002WARNING@ PLEASE READ THIS MANUAL CAREFULLY AND COMPLETELY BEFORE OPERATINGTHIS MOTORCYCLE. @

OPERATION AND IMPORTANT RIDING POINTS5-45EAU01258Starting a warm engineThe starter (choke) is not requiredwhen the engine is warm.EC000046CAUTION:@ Se

OPERATION AND IMPORTANT RIDING POINTS5-55EAU02941Recommended shift points (for Switzerland only)The recommended shift points areshown in the table bel

OPERATION AND IMPORTANT RIDING POINTS5-65EAU01329*0 ~ 1,000 kmAvoid operation above 4,000 r/min.1,000 ~ 1,600 kmAvoid cruising speeds in excess of5,00

6PERIODIC MAINTENANCE AND MINOR REPAIRTool kit...6-1Periodic maintenance and lubricati

6-16EAU004626-PERIODIC MAINTENANCE AND MINOR REPAIREAU00464Periodic inspection, adjustment and lu-brication will keep your motorcycle inthe safest and

PERIODIC MAINTENANCE AND MINOR REPAIR6-26EAU00473PERIODIC MAINTENANCE AND LUBRICATIONCP-01ENO. ITEM CHECKS AND MAINTENANCE JOBSINITIAL(1,000 km)EVERY6

PERIODIC MAINTENANCE AND MINOR REPAIR6-3610*Tires• Check tread depth and for damage.• Replace if necessary.• Check air pressure.• Correct if necessary

PERIODIC MAINTENANCE AND MINOR REPAIR6-46* Since these items require special tools, data and technical skills, they should be serviced by a Yamaha dea

PERIODIC MAINTENANCE AND MINOR REPAIR6-56EAU01777Panel removal and installationThe panel illustrated needs to be re-moved to perform some of the maint

IMPORTANT MANUAL INFORMATIONEAU00008XJR1300/XJR1300SPOWNER’S MANUAL© 1999 by Yamaha Motor Co., Ltd.1st Edition, July 1999All rights reserved. Any repr

PERIODIC MAINTENANCE AND MINOR REPAIR6-66EAU03053Spark plugsRemoval1. Remove the spark plug caps.2. Use the spark plug wrench in thetool kit to remove

PERIODIC MAINTENANCE AND MINOR REPAIR6-76Installation1. Measure the electrode gap with awire thickness gauge and, if nec-essary, adjust the gap to spe

PERIODIC MAINTENANCE AND MINOR REPAIR6-862. With the engine stopped, checkthe oil level through the level win-dow located at the lower part ofthe righ

PERIODIC MAINTENANCE AND MINOR REPAIR6-966. Install the new oil filter elementand O-ring.7. Align the projection on the filtercover with the slot in h

PERIODIC MAINTENANCE AND MINOR REPAIR6-10610. Start the engine and warm it up forseveral minutes. While warmingup, check for oil leakage. If oilleakag

PERIODIC MAINTENANCE AND MINOR REPAIR6-1165. Tap the air filter lightly to removemost of the dust and dirt and blowout the remaining dirt with com-pre

PERIODIC MAINTENANCE AND MINOR REPAIR6-1262. Set the idle to the specified enginespeed by adjusting the throttlestop screw. Turn the screw in di-recti

PERIODIC MAINTENANCE AND MINOR REPAIR6-136EAU00658TiresTo ensure maximum performance,long service and safe operation, notethe following:Tire air press

PERIODIC MAINTENANCE AND MINOR REPAIR6-146Tire inspectionAlways check the tires before operatingthe motorcycle. If center tread depthreaches the limit

PERIODIC MAINTENANCE AND MINOR REPAIR6-156EW000080WARNING@ ●After extensive tests, the tiresmentioned below have been ap-proved by Yamaha Motor Co.,Lt

TABLE OF CONTENTS1 GIVE SAFETY THE RIGHT OF WAY12 DESCRIPTION23 INSTRUMENT AND CONTROL FUNCTIONS34 PRE-OPERATION CHECKS45 OPERATION AND IMPORTANT RIDI

PERIODIC MAINTENANCE AND MINOR REPAIR6-166EAU00687WheelsTo ensure maximum performance,long service, and safe operation, notethe following:●Always insp

PERIODIC MAINTENANCE AND MINOR REPAIR6-176EAU01756Brake light switch adjustmentThe rear brake light switch is activatedby the brake pedal and is prope

PERIODIC MAINTENANCE AND MINOR REPAIR6-186EAU01800*Inspecting the brake fluid levelInsufficient brake fluid may let air enterthe brake or clutch syste

PERIODIC MAINTENANCE AND MINOR REPAIR6-196EAU00742Brake fluid replacementThe brake fluid should be replaced onlyby trained Yamaha service personnel.Ha

PERIODIC MAINTENANCE AND MINOR REPAIR6-206EC000096CAUTION:@ Too little chain slack will overloadthe engine and other vital parts.Keep the slack within

PERIODIC MAINTENANCE AND MINOR REPAIR6-216EAU00773Throttle cable and grip lubricationThe throttle twist grip assembly shouldbe greased at the time tha

PERIODIC MAINTENANCE AND MINOR REPAIR6-226EAU02965Center and sidestand lubricationLubricate the pivoting and matingjoints. Check to see that the cente

PERIODIC MAINTENANCE AND MINOR REPAIR6-236EAU00794Steering inspectionPeriodically inspect the condition of thesteering. Worn out or loose steeringbear

PERIODIC MAINTENANCE AND MINOR REPAIR6-246EW000116WARNING@ Battery electrolyte is poisonous anddangerous, causing severe burns,etc. It contains sulfur

PERIODIC MAINTENANCE AND MINOR REPAIR6-256EAU01470Fuse replacementThe fuse box is located under the seat.(See page 3-11 for seat removal andinstallati

PERIODIC MAINTENANCE AND MINOR REPAIR6-2662. Remove the headlight connectorand the bulb cover.3. Unhook the bulb holder and re-move the defective bulb

PERIODIC MAINTENANCE AND MINOR REPAIR6-276EAU00856*Tail/brake light bulb replacement1. Remove the seat.2. To remove the socket, turn it coun-terclockw

PERIODIC MAINTENANCE AND MINOR REPAIR6-286EAU00869Front wheel removalEW000122WARNING@ ●It is advisable to have a Yamahadealer service the wheel.●Secur

PERIODIC MAINTENANCE AND MINOR REPAIR6-296EAU01758*Front wheel installation1. Install the speedometer gear unithousing into the wheel hub. Makesure th

PERIODIC MAINTENANCE AND MINOR REPAIR6-306EAU01318Rear wheel removalEW000122WARNING@ ●It is advisable to have a Yamahadealer service the wheel.●Secure

PERIODIC MAINTENANCE AND MINOR REPAIR6-316EAU01317Rear wheel installation1. Install the caliper bracket andwheel assembly, then insert theaxle.2. Inst

PERIODIC MAINTENANCE AND MINOR REPAIR6-326EAU01297Troubleshooting chartEW000125WARNING@ Never check the fuel system while smoking or in the vicinity o

7MOTORCYCLE CARE AND STORAGECare ... 7-1Storage...

7-17EAU015177-MOTORCYCLE CARE AND STORAGECareThe exposure of its technology makesa motorcycle charming but also vulner-able. Although high-quality com

1GIVE SAFETY THE RIGHT OF WAYGIVE SAFETY THE RIGHT OF WAY... 1-1

MOTORCYCLE CARE AND STORAGE7-27ECA00010CAUTION:@ ●Avoid using strong acidic wheelcleaners, especially on spokedwheels. If you do use suchproducts for

MOTORCYCLE CARE AND STORAGE7-371. Clean your motorcycle with coldwater and soap after the enginehas cooled down.ECA00012CAUTION:@ Do not use warm wate

MOTORCYCLE CARE AND STORAGE7-47ECA00013CAUTION:@ ●Apply spray oil and wax spar-ingly and wipe off any excess.●Never apply oil or wax on rub-ber and pl

MOTORCYCLE CARE AND STORAGE7-57a. Remove the spark plug caps andspark plugs.b. Pour a teaspoonful of engine oilinto each spark plug bore.c. Install th

8SPECIFICATIONSSpecifications... 8-1HOW TO USE THE CONVERSION TABLE.

8-18EAU010388-SPECIFICATIONSSpecificationsModel XJR1300/XJR1300SPDimensionsOverall length 2,250 mm (for SF, N, S)2,175 mm (except for SF, N, S)Overall

SPECIFICATIONS8-28FuelType Regular unleaded gasolineFuel tank capacity 21 LFuel reserve amount 4.5 LCarburetorType × quantity BS36 × 4Manufacturer MIK

SPECIFICATIONS8-3890 kg load ~ maximum load*Front 250 kPa (2.50 kg/cm2, 2.50 bar)Rear 290 kPa (2.90 kg/cm2, 2.90 bar)High speed ridingFront 250 kPa (2

SPECIFICATIONS8-48Bulb voltage, wattage × quantityHeadlight 12 V, 60/55 W × 1Tail/brake light 12 V, 5/21 W × 2Auxiliary light 12 V, 4 W × 1Turn signal

SPECIFICATIONS8-58EAU01064HOW TO USE THE CONVERSION TABLECS-02E All specification data in this manual are listed in SI andMETRIC UNITS. Use this tabl

11-11-GIVE SAFETY THE RIGHT OF WAYEAU00021Motorcycles are fascinating vehicles, which can give you an unsurpassed feeling of power andfreedom. However

9CONSUMER INFORMATIONIdentification number records... 9-1Key identification number ...

9-19EAU010399-CONSUMER INFORMATIONEAU02944Identification number recordsRecord the key identification number,vehicle identification number and mod-el l

CONSUMER INFORMATION9-29EAU01050Model labelThe model label is affixed to the frameunder the seat. (See page 3-11 for seatremoval procedures.) Record t

10-INDEXAAir filter ...6-10Antitheft alarm (optional)...3-4BBattery...

INDEXSSeat.....3-11Shifting ..... 5-4Shift pedal ...

PRINTED IN JAPAN99 · 7 - 0.3 × 1 CR(E)PRINTED ON RECYCLED PAPER YAMAHA MOTOR CO., LTD.