Yamaha VINO 125 Service Manual Page 86
- Page / 294
- Table of contents
- TROUBLESHOOTING
- BOOKMARKS
Rated. / 5. Based on customer reviews
3-38
CHK
ADJ
EAS00148
CHECKING AND ADJUSTING THE STEER-
ING HEAD
1. Stand the scooter on a level surface.
w
Securely support the scooter so that there
is no danger of it falling over.
NOTE:
Place the scooter on a suitable stand so that
the front wheel is elevated.
2. Check:
8steering head
Grasp the bottom of the front fork legs
and gently rock the front fork.
Binding/looseness J Adjust the steering
head.
3. Remove:
8head light cover
8front turn signal light bracket
8leg shield 1
Refer to “COVER AND PANEL”.
4. Adjust:
8steering head
*****************************************************
a. Remove the upper ring nut 1, the lock
washer 2, the center ring nut 3 and the
rubber washer 4.
b. Loosen the lower ring nut 5 and then
tighten it to specification with the steering
nut wrench 6.
NOTE:
Set the torque wrench at a right angle to the
steering nut wrench.
Steering nut wrench
90890-01403
YU-33975
Lower ring nut (initial tightening
torque)
28 Nm (2.8 m • kg, 20.3 ft • lb)
CHECKING AND ADJUSTING THE STEERING HEAD
T
R
.
.
3
4
1
2
5
6
- SERVICE MANUAL 1
- EAS00000 2
- IMPORTANT MANUAL INFORMATION 3
- HOW TO USE THIS MANUAL 4
- EAS00008 5
- TABLE OF CONTENTS 6
- GENERAL INFORMATION 8
- IMPORTANT INFORMATION 10
- CHECKING THE CONNECTIONS 11
- SPECIAL TOOLS 12
- SPECIFICATIONS 16
- SAE 10W-30 17
- SAE 10W-40 17
- SAE 20W-40 17
- SAE 20W-50 17
- ENGINE SPECIFICATIONS 18
- CHASSIS SPECIFICATIONS 26
- ELECTRICAL SPECIFICATIONS 29
- TORQUE SPECIFICATIONS 33
- TIGHTENING TORQUES 34
- BEL-RAY asembly lube 38
- OIL FLOW DIAGRAMS 40
- CABLE ROUTING 42
- INTRODUCTION 49
- EMISSION CONTROL SYSTEM 50
- EAU32121 51
- EAU17620 51
- COVER AND PANEL 52
- ADJUSTING THE VALVE CLEARANCE 55
- EAS00054 58
- EAS00057 61
- CHECKING THE SPARK PLUG 63
- CHECKING THE IGNITION TIMING 64
- EAS00067 65
- CHECKING THE ENGINE OIL LEVEL 68
- CHECKING THE ENGINE OIL 69
- CHANGING THE TRANSMISSION OIL 72
- EAS00077 73
- EAS00086 74
- EAS00091 74
- CHECKING THE CARBURETOR JOINT 76
- AND INTAKE MANIFOLD 76
- EAS00096 77
- EAS00098 77
- CHECKING THE EXHAUST SYSTEM 78
- ADJUSTING THE FRONT BRAKE/ 79
- ADJUSTING THE REAR BRAKE 79
- EAS00116 80
- CHECKING THE FRONT BRAKE HOSE 81
- BRAKE FLUID CHANGE 82
- EAS00133 84
- EAS00148 86
- CHECKING THE FRONT FORK 88
- EAS00163 89
- CHECKING THE TIRES 90
- CHECKING THE WHEELS/ 92
- LUBRICATING THE SIDESTAND/ 93
- LUBRICATING THE CENTERSTAND 93
- ELECTRICAL SYSTEM 94
- Open-circuit voltage (V) 96
- Voltmeter 99
- CHECKING THE FUSES 100
- REPLACING THE HEADLIGHT BULB 102
- ADJUSTING THE HEADLIGHT BEAMS 103
- FRONT WHEEL AND BRAKE DISC 106
- FRONT WHEEL 107
- REAR WHEEL AND REAR BRAKE 116
- FRONT BRAKE 120
- FRONT FORK 138
- HANDLEBAR 148
- STEERING HEAD 152
- REAR SHOCK ABSORBER 158
- EAS00188 162
- RemarksOrder Job/Part Q’ty 163
- EAS00192 164
- • kg, 5.1 ft • lb) 165
- • kg, 22.4 ft • lb) 165
- • kg, 7.2 ft • lb) 165
- CYLINDER HEAD 166
- THE ROCKER ARMS AND CAMSHAFT 174
- VALVES AND VALVE SPRINGS 180
- Valve stem diameter b 182
- CYLINDER AND PISTON 189
- Piston size “P” 191
- Piston pin bore diameter b 193
- Piston pin outside diameter a 193
- BELT DRIVE 196
- C.D.I. MAGNETO 211
- OIL PUMP 214
- TRANSMISSION 217
- CRANKCASE AND CRANKSHAFT 219
- CARBURETOR 227
- Starter plunger opens 234
- Perform step (3) 234
- Starter plunger closes 234
- Replace the autochoke unit 234
- AIR INDUCTION SYSTEM 236
- ELECTRICAL 239
- WIRING DIAGRAM 240
- CHECKING SWITCH CONTINUITY 242
- CHECKING THE SWITCHES 243
- CHECKING THE BULBS AND BULB 244
- IGNITION SYSTEM 247
- ELECTRIC STARTING SYSTEM 252
- CHARGING SYSTEM 262
- LIGHTING SYSTEM 265
- SIGNALING SYSTEM 271
- CARBURETOR HEATING SYSTEM 279
- CRABURETOR HEATING SYSTEM 279
- AUTO CHOKE SYSTEM 283
- TROUBLESHOOTING 288
- STARTING FAILURES/ 289
- INCORRECT ENGINE IDLING SPEED 289
- INCORRECT ENGINE IDLING 289
- FAULTY CLUTCH 290
- POOR MEDIUM-AND-HIGH-SPEED 290
- PERFORMANCE 290
- OVERHEATING 291
- POOR BRAKING PERFORMANCE 291
- FAULTY FRONT FORK LEGS 291
- UNSTABLE HANDLING/ 292
- UNSTABLE HANDLING 292
- FAULTY LIGHTING OR SIGNALING 292
- YAMAHA MOTOR TAIWAN CO., LTD 294
Related products and manuals for Scooters Yamaha VINO 125
Scooters Yamaha VXR Operator's Manual
(28 pages)
(28 pages)
Scooters Yamaha BWS YW100E Owner's Manual
(63 pages)
(63 pages)
Scooters Yamaha YQ50/YQ50L Owner's Manual
(84 pages)
(84 pages)
Scooters Yamaha NEO'S YN50 Owner's Manual
(72 pages)
(72 pages)
Scooters Yamaha BWS CW50RS Owner's Manual
(80 pages)
(80 pages)
Scooters Yamaha SLIDER EW50 Owner's Manual
(80 pages)
(80 pages)
Scooters Yamaha AEROX YQ50 Owner's Manual
(68 pages)
(68 pages)
Scooters Yamaha YW125Z User Manual
(38 pages)
(38 pages)
Scooters Yamaha BWS CW50L Owner's Manual
(68 pages)
(68 pages)
Scooters Yamaha EC-03 Owner's Manual
(78 pages)
(78 pages)
Scooters Yamaha VXS User Manual
(6 pages)
(6 pages)
Scooters Yamaha MAJESTY YP180E User Manual
(28 pages)
(28 pages)
Scooters Yamaha CYGNUS RS XC125E User Manual
(13 pages)
(13 pages)
Scooters Yamaha Xenter HW151 User Manual
(1 pages)
(1 pages)
Scooters Yamaha MAJESTY YP180E User Manual
(57 pages)
Scooters Yamaha why YH50 Owner's Manual
(80 pages)
(80 pages)
© 2020, manymanuals.com. All rights reserved. | 2.475 s |
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Comments to this Manuals