Yamaha YDRA Operator's Manual download pdf (Page 47)

SPECIFICATIONS

10-3

JW1

BATTERIES

Items YDRA

Battery: BCI group 24,

RC: minimum 75 min

CCA: minimum 400A

CHASSIS

Items YDRA

Steering system:

Type Rack and Pinion

Steering angle (L.H.) 1.85 turn

Steering angle (R.H.) 1.85 turn

Brakes:

Brake system Mechanical

Type of brake Maintenance-Free internal transaxle disc brake

Brake pedal free play linkage

adjustment 45-50 mm

(1.77-1.96 in.)

(Brake cable end play) 0.1-0.5 mm (0.004-0.02 in.)

Parking brake:

Type Foot type; parking brake with automatic

release.

Release timing

(With pedal segment in second

notch)

(Bolt heads round parallel to arm) 0.0 ~ 0.3 mm (0.000 ~ 0.001 in.)

Wheel:

Tire size:

Front 18 x 8.50–8.00/4 PR

Rear 18 x 8.50–8.00/4 PR

Rim size: 7.00–I–8.00

Tire pressure: 110 kPa, 1.1 kgf/cm

(16 psi)

LIT_19626_11_09:LIT_19626_16_05.qxd 5/19/09 9:34 AM Page 44

1-2

JW1

WARRANTY

The California Air Resources Board and Yamaha

Golf-Car Company are pleased to explain the emis-

sions control system warranty on your 2008 small off-

road engine (SORE) vehicle. In California, new

SORE vehicles must be designed, built and equipped

to meet the State’s stringent anti-smog standards.

Yamaha Golf-Car Company must warrant the EECS

on your SORE vehicle for the period of time listed

below provided there has been no abuse, neglect or

improper maintenance of your SORE vehicle.

Your EECS may include parts such as the carburetor,

fuel-injection system, the ignition system, catalytic

converter, fuel tanks, fuel lines, fuel caps, valves,

canisters, filters, vapor hoses, clamps, connectors,

and other associated emission-related components.

Where a warrantable condition exists, Yamaha Golf-

Car Company will repair your SORE vehicle at no

cost to you including diagnosis, parts and labor.

MANUFACTURER’S WARRANTY COVERAGE:

This emissions control system is warranted for two

years. If any emission-related part on your equip-

ment is defective, the part will be repaired or

replaced by Yamaha Golf-Car Company.

OWNER’S WARRANTY RESPONSIBILITIES:

As the SORE vehicle owner, you are responsible for

performance of the required maintenance listed in your

owner’s manual. Yamaha Golf-Car Company recom-

mends that you retain all receipts covering mainte-

nance on your SORE vehicle, but Yamaha Golf-Car

Company cannot deny warranty solely for the lack of

receipts.

As the SORE vehicle owner, you should however be

aware that Yamaha Golf-Car Company may deny you

warranty coverage if your SORE vehicle or a part has

failed due to abuse, neglect, or improper maintenance

or unapproved modifications.

You are responsible for presenting your SORE vehicle

to Yamaha Golf-Car Company’s distribution center or

service center as soon as the problem exists. The war-

ranty repairs should be completed in a reasonable

amount of time, not to exceed 30 days. If you have a

question regarding your warranty coverage, you should

contact YGC Service at 1-866-747-4027.

GENERAL EMISSIONS WARRANTY COVERAGE:

Yamaha Golf-Car Company warrants to the ultimate

purchaser and each subsequent purchaser that the

SORE vehicle is:

Designed, built and equipped so as to conform with all

applicable regulations; and

Free from defects in materials and workmanship that

cause the failure of a warranted part to be identical in

all material respects to that part as described in

Yamaha Golf-Car Company’s application for certifica-

tion.

The warranty period begins on the date the SORE

vehicle is delivered to an ultimate purchaser or first

placed into service. The warranty period is two years.

Subject to certain conditions and exclusions as stated

below, the warranty on emission-related parts is as fol-

lows:

1. Any warranted part that is not scheduled for

replacement as required maintenance in the writ-

ten instructions supplied, is warranted for the war-

ranty period stated above. If the part fails during

the period of warranty coverage, the part will be

repaired or replaced by Yamaha Golf-Car

Company according to subsection (4) below. Any

such part repaired or replaced under warranty will

be warranted for the remainder of the period.

2. Any warranted part that is scheduled only for regu-

lar inspection in the written instructions supplied is

warranted for the warranty period stated above.

Any such part repaired or replaced under warranty

will be warranted for the remaining warranty

period.

3. Any warranted part that is scheduled for replace-

ment as required maintenance in the written

instructions supplied is warranted for the period of

time before the first scheduled replacement date

for that part. If the part fails before the first sched-

uled replacement, the part will be repaired or

replaced by Yamaha Golf-Car Company according

to subsection (4) below. Any such part repaired or

replaced under warranty will be warranted for the

remainder of the period prior to the first scheduled

replacement point for the part.

4. Repair or replacement of any warranted part under

the warranty provisions herein must be performed

at a warranty station at no charge to the owner.

5. Notwithstanding the provisions herein, warranty

services or repairs will be provided at all of our dis-

tribution centers that are franchised to service the

subject engines or equipment.

6. The SORE vehicle owner will not be charged for

diagnostic labor that is directly associated with

diagnosis of a defective, emission-related warrant-

ed part, provided that such diagnostic work is per-

formed at a warranty station.

7. Yamaha Golf-Car Company is liable for damages

to other engine or equipment components proxi-

mately caused by a failure under warranty of any

warranted part.

CALIFORNIA EMISSION CONTROL WARRANTY STATEMENT

YOUR WARRANTY RIGHTS AND OBLIGATIONS

LIT_19626_11_09:LIT_19626_16_05.qxd 5/19/09 9:34 AM Page 5

1 2 ... 42 43 44 45 46 47 48 49 50

Comments to this Manuals

No comments

Yamaha YDRA Operator's Manual Page 47

Comments to this Manuals

Related products and manuals for Engine Yamaha YDRA