Yamaha VINO XC50V Service Manual Page 85
- Page / 298
- Table of contents
- TROUBLESHOOTING
- BOOKMARKS
Rated. / 5. Based on customer reviews
3-34
CHK
ADJ
EAS00103
CHECKING THE COOLANT LEVEL
1. Stand the scooter on a level surface.
NOTE:
8 Place the scooter on a suitable stand.
8 Make sure the scooter is upright.
2. Remove:
8mat
8battery cover
Refer to “COVER AND PANEL”.
3. Check:
8coolant level
The coolant level should be between the
maximum level mark a and minimum
level mark b.
Below the minimum level mark J Add
the recommended coolant to the proper
level.
cC
88
88
8 Adding water instead of coolant lowers
the antifreeze content of the coolant. If
water is used instead of coolant check,
and if necessary, correct the antifreeze
concentration of the coolant.
88
88
8 Use only distilled water. However, if dis-
tilled water is not available, soft water
may be used.
4. Start the engine, warm it up for several min-
utes, and then turn it off.
5. Check:
8coolant level
NOTE:
Before checking the coolant level, wait a few
minutes until it settles.
6. Install:
8 battery cover
8 mat
Refer to “COVER AND PANEL”.
CHECKING THE COOLANT LEVEL
a
b
- SERVICE MANUAL 1
- EAS00000 2
- IMPORTANT MANUAL INFORMATION 3
- HOW TO USE THIS MANUAL 4
- EAS00008 5
- TABLE OF CONTENTS 6
- GENERAL INFORMATION 8
- IMPORTANT INFORMATION 10
- CHECKING THE CONNECTIONS 12
- SPECIAL TOOLS 13
- SPECIFICATIONS 17
- SAE 10W-30 18
- SAE 10W-40 18
- SAE 20W-40 18
- SAE 20W-50 18
- ENGINE SPECIFICATIONS 19
- CHASSIS SPECIFICATIONS 26
- ELECTRICAL SPECIFICATIONS 28
- TORQUE SPECIFICATIONS 31
- TIGHTENING TORQUES 32
- EAS00031 35
- Lubrication Point Lubricant 36
- Crankcase mating surfaces 36
- COOLING SYSTEM DIAGRAMS 38
- OIL FLOW DIAGRAMS 42
- CABLE ROUTING 44
- INTRODUCTION 52
- EAU17560* 53
- EAU17680 55
- COVER AND PANEL 56
- ADJUSTING THE VALVE CLEARANCE 60
- EAS00054 65
- EAS00057 68
- CHECKING THE SPARK PLUG 69
- CHECKING THE IGNITION TIMING 70
- EAS00067 72
- EAS00076 75
- CHANGING THE ENGINE OIL 76
- CHANGING THE TRANSMISSION OIL 77
- EAS00077 78
- EAS00086 80
- EAS00094 81
- EAS00096 81
- EAS00097 82
- EAS00098 83
- EAS00099 84
- CHECKING THE COOLANT LEVEL 85
- CHECKING THE COOLING SYSTEM 86
- CHANGING THE COOLANT 87
- ADJUSTING THE FRONT BRAKE/ 90
- ADJUSTING THE REAR BRAKE 90
- EAS00127 91
- EAS00148 92
- CHECKING THE FRONT FORK 94
- CHECKING THE TIRES 95
- D R I V E 97
- CHECKING THE WHEELS/ 98
- LUBRICATING THE CENTERSTAND 99
- ELECTRICAL SYSTEM 100
- Open-circuit voltage (V) 102
- Voltmeter 105
- CHECKING THE FUSE 106
- Main 7.5A 1 107
- REPLACING THE HEADLIGHT BULB 108
- ADJUSTING THE HEADLIGHT BEAM 109
- FRONT WHEEL AND BRAKE 112
- REAR WHEEL AND BRAKE 124
- FRONT FORK 130
- HANDLEBAR 136
- STEERING HEAD 141
- EAS00684 144
- REAR SHOCK ABSORBER ASSEMBLY 145
- 12Nm (1.2 m•kg, 8.7 ft•lb) 150
- 16Nm (1.6 m•kg, 11.6 ft•lb) 150
- 10Nm (1.0 m•kg, 7.2 ft•lb) 150
- 46Nm (4.6 m•kg, 33.3 ft•lb) 150
- 8Nm (0.8 m•kg, 5.8 ft•lb) 152
- 13Nm (1.3 m•kg, 9.4 ft•lb) 152
- 31Nm (3.1 m•kg, 22.4 ft•lb) 152
- EAS00192 153
- CYLINDER HEAD 154
- THE ROCKER ARMS AND CAMSHAFT 161
- VALVES AND VALVE SPRINGS 167
- Valve stem diameter b 169
- EAS00245 174
- CYLINDER AND PISTON 176
- Piston pin bore diameter b 180
- Piston pin outside diameter a 180
- BELT DRIVE 183
- EAS00318 187
- EAS00317 187
- STARTER CLUTCH AND AC MAGNETO 195
- EAS00347 198
- EAS00354 201
- EAS00355 201
- OIL PUMP 203
- TRANSMISSION 206
- CRANKSHAFT 208
- EAS00408 214
- EAS00418 214
- COOLING SYSTEM 216
- RADIATOR 217
- THERMOSTAT ASSEMBLY 219
- EAS00462 221
- WATER PUMP 223
- EAS00475 226
- EAS00478 227
- CARBURETOR 229
- AIR INDUCTION SYSTEM 240
- ELECTRICAL 243
- WIRING DIAGRAM 244
- CHECKING SWITCH CONTINUITY 246
- CHECKING THE SWITCHES 247
- CHECKING THE BULBS AND BULB 248
- IGNITION SYSTEM 251
- ELECTRIC STARTING SYSTEM 256
- EAS00772 264
- CHARGING SYSTEM 265
- LIGHTING SYSTEM 268
- SIGNALING SYSTEM 274
- AUTO CHOKE SYSTEM 287
- TROUBLESHOOTING 292
- INCORRECT ENGINE IDLING SPEED 293
- INCORRECT ENGINE IDLING 293
- FAULTY CLUTCH 294
- POOR MEDIUM-AND-HIGH 294
- SPEED PERFORMANCE 294
- OVERHEATING 295
- OVERCOOLING 295
- FORK LEGS/UNSTABLE HANDLING 296
- POOR BRAKING PERFORMANCE 296
- FAULTY FRONT FORK LEGS 296
- UNSTABLE HANDLING 296
- FAULTY LIGHTING OR SIGNALING 297
- YAMAHA MOTOR TAIWAN CO., LTD 298
Related products and manuals for Motorcycles Yamaha VINO XC50V
Motorcycles Yamaha TTR90(M) Service Manual
(132 pages)
(132 pages)
Motorcycles Yamaha TW200C Service Manual
(109 pages)
(109 pages)
Motorcycles Yamaha 1100 Service Manual
(355 pages)
(355 pages)
Motorcycles Yamaha XV19CSD Owner's Manual
(96 pages)
(96 pages)
Motorcycles Yamaha XS650SG Specifications
(215 pages)
(215 pages)
Motorcycles Yamaha XT250D Owner's Manual
(100 pages)
(100 pages)
Motorcycles Yamaha FZ6RB(C) Owner's Manual
(116 pages)
(116 pages)
Motorcycles Yamaha YZFR1Y(C) Specifications
(20 pages)
(20 pages)
Motorcycles Yamaha Star XVS13CAC User Manual
(20 pages)
(20 pages)
Motorcycles Yamaha FZS10VC Owner's Manual
(104 pages)
(104 pages)
Motorcycles Yamaha VINO 125 Owner's Manual
(88 pages)
(88 pages)
Motorcycles Yamaha RX-10 Owner's Manual
(101 pages)
(101 pages)
Motorcycles Yamaha YFM350XP Service Manual
(29 pages)
(29 pages)
Motorcycles Yamaha YZF-R1S Owner's Manual
(114 pages)
(114 pages)
Motorcycles Yamaha YZF-R1 2000 Service Manual
(417 pages)
(417 pages)
Motorcycles Yamaha XT225VC Owner's Manual
(97 pages)
(97 pages)
Motorcycles Yamaha TW125 (5RS1) User Manual
(51 pages)
(51 pages)
© 2020, manymanuals.com. All rights reserved. | 0.044 s |
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Comments to this Manuals