Yamaha F115C Owner's Manual Page 85
- Page / 116
- Table of contents
- TROUBLESHOOTING
- BOOKMARKS
Rated. / 5. Based on customer reviews
E
4-22
EMU00976
Removing the Propeller
1) Straighten the cotter-pin 1 and pull it
out using a pair of pliers.
2) Remove the propeller nut 2, washer
3 and spacer 4.
3) Remove the propeller 5 and thrust
washer 6.
000357
q
w
e
t
y
r
EMU00397
Installing the Propeller
cC
8 Be sure to install the thrust washer
before installing propeller, otherwise,
lower case and propeller boss may be
damaged.
8 Be sure to use a new cotter pin and
bend the ends over securely.
Otherwise, the propeller could come off
during operation and be lost.
1) Apply Yamaha Marine grease or
Corrosion resistant grease to the pro-
peller-shaft.
2) Install the thrust washer and propeller
on the propeller-shaft.
3) Install the spacer and washer. Tighten
the propeller nut to the specified
torque.
4) Align the propeller nut with the pro-
peller shaft hole. Insert a new cotter
pin in the hole and bend the cotter pin
ends.
NOTE:
If the propeller nut does not align with the
propeller shaft hole after tightening to the
specified torque, then tighten the nut fur-
ther to align it with the hole.
Tightening torque:
Refer to “SPECIFICATIONS” page 4-1.
602053
68V-9-14-4 3/11/03 19:35 Page 23
- OWNER’S MANUAL 1
- TO THE OWNER 3
- CONTENTS 4
- Chapter 1 5
- INFORMATION 5
- IDENTIFICATION NUMBERS 6
- EMISSION CONTROL 7
- STAR LABELS 8
- IMPORTANT LABELS 11
- BASIC BOATING RULES 12
- (Rules of the road) 12
- RULES WHEN ENCOUNTERING 13
- OTHER SPECIAL SITUATIONS 14
- MAIN CHANNEL 15
- FUELING INSTRUCTIONS 16
- ENGINE OIL 17
- BATTERY REQUIREMENT 18
- PROPELLER SELECTION 19
- START-IN-GEAR PROTECTION 20
- Chapter 2 21
- BASIC COMPONENTS 21
- MAIN COMPONENTS 22
- OPERATIONS OF CONTROLS 23
- OTHER FUNCTIONS 23
- EMU00098 24
- EMU00099 24
- EMU00100 24
- STARTOFF 25
- EMU01112 26
- 1 Fully-open 27
- 2 Fully-closed 27
- 3 Free accelerator 27
- TRIM TAB 28
- POWER TRIM/TILT SWITCH 29
- DIGITAL TACHOMETER 30
- EMU01109 31
- EMU01620 31
- 1 Overheat warning indicator 32
- DIGITAL SPEEDOMETER 33
- TRIP TIME BATT 34
- FUEL MANAGEMENT 36
- TOP COWLING LOCK LEVERS 40
- FLUSHING DEVICE 40
- OFF START OFF START 41
- Chapter 3 43
- OPERATION 43
- INSTALLATION 44
- MOUNTING THE OUTBOARD 45
- EMU01299 46
- BREAKING IN (RUNNING IN) 47
- PRE-OPERATION CHECKS 48
- CHECKING THE ENGINE OIL LEVEL 49
- FILLING FUEL 50
- STARTING ENGINE 51
- EMU00949 53
- WARMING UP ENGINE 54
- SHIFTING 55
- STOPPING ENGINE 56
- TRIMMING OUTBOARD 57
- ADJUSTING TRIM ANGLE 58
- 2 Bow up 59
- 3 Bow down 59
- TILTING UP/DOWN 60
- PROCEDURE FOR TILTING UP 61
- CRUISING IN OTHER 62
- CONDITIONS 62
- Chapter 4 63
- MAINTENANCE 63
- SPECIFICATIONS 64
- TRAILERING OUTBOARD MOTOR 66
- STORING OUTBOARD MOTOR 67
- EMU00335 68
- EMU00338 68
- EMU00342 68
- EMU00349* 69
- EMU00352 70
- EMU00353 70
- UPPER LEVEL 71
- LOWER LEVEL 71
- PERIODIC MAINTENANCE 72
- MAINTENANCE CHART 73
- GREASING 74
- CLEANING AND ADJUSTING SPARK 75
- CHECKING TOP COWLING 76
- CHECKING FUEL SYSTEM 77
- INSPECTING FUEL FILTER 78
- CHANGING ENGINE OIL 79
- REPLACING FUSE 81
- EMU00383 82
- EMU00384 82
- EMU00385 82
- EMU00993 82
- CHECKING PROPELLER 84
- EMU00976 85
- EMU00397 85
- CHANGING GEAR OIL 86
- INSPECTING AND REPLACING 88
- ANODE(S) 88
- EMU04041 89
- CLEANING COOLING-WATER 92
- PASSAGES 92
- COATING THE BOAT BOTTOM 93
- MOTOR EXTERIOR 93
- – MEMO – 94
- Chapter 5 95
- TROUBLE RECOVERY 95
- TROUBLESHOOTING 96
- TEMPORARY ACTION IN 100
- EMERGENCY 100
- POWER TRIM/TILT WILL NOT 101
- STARTER WILL NOT OPERATE 102
- ON STARTOFF 103
- TREATMENT OF SUBMERGED 104
- Chapter 6 105
- EMU00451 106
- EMU01599 108
- FOUR-STROKE OUTBOARD MOTOR 110
- THREE-YEAR LIMITED WARRANTY 110
- EMU01178 113
- YAMAHA MOTOR CO., LTD 115
- MADE IN JAPAN 115
- PAYS D'ORIGINE JAPON 115
- ATTN: WARRANTY DEPARTMENT 116
Related products and manuals for Engine Yamaha F115C
Engine Yamaha LZ250C Service Manual
(90 pages)
(90 pages)
Engine Yamaha T9.9B Owner's Manual
(124 pages)
(124 pages)
Engine Yamaha F115D Owner's Manual
(82 pages)
(82 pages)
Engine Yamaha F-20 Owner's Manual
(98 pages)
(98 pages)
Engine Yamaha 50D Owner's Manual
(77 pages)
(77 pages)
Engine Yamaha 15D Owner's Manual
(64 pages)
(64 pages)
Engine Yamaha YDRA Operator's Manual
(50 pages)
(50 pages)
Engine Yamaha F150C Owner's Manual
(80 pages)
(80 pages)
Engine Yamaha 150A Owner's Manual
(131 pages)
(131 pages)
Engine Yamaha 200A Service Manual
(56 pages)
(56 pages)
Engine Yamaha LF200D Owner's Manual
(114 pages)
(114 pages)
Engine Yamaha E40X Owner's Manual
(82 pages)
(82 pages)
Engine Yamaha EL-25 Owner's Manual
(80 pages)
(80 pages)
Engine Yamaha F350A2 Owner's Manual
(138 pages)
(138 pages)
Engine Yamaha 15B Owner's Manual
(100 pages)
(100 pages)
Engine Yamaha 8 Owner's Manual
(94 pages)
(94 pages)
Engine Yamaha YDRA Operator's Manual
(47 pages)
(47 pages)
Engine Yamaha LX200A Owner's Manual
(125 pages)
(125 pages)
Engine Yamaha T-50 Owner's Manual
(96 pages)
(96 pages)
© 2020, manymanuals.com. All rights reserved. | 0.925 s |
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Comments to this Manuals