Yamaha 115D Owner's Manual download pdf (Page 48)

Maintenance

43

NOTE:

A flushing attachment is available from your

Yamaha dealer.

EMU28410

Lubrication (oil injection models)

1. Grease the spark plug threads and in-

stall the spark plug(s) and torque to

proper specification. For information on

spark plug installation, see page 48.

2. Fill the oil tanks. This prevents the for-

mation of condensation. For models with

a remote oil tank, it may be necessary to

manually override the control unit to

completely fill the engine oil tank.

3. Change the gear oil. For instructions,

see page 55. Inspect the oil for the pres-

ence of water which indicates a leaky

seal. Seal replacement should be per-

formed by an authorized Yamaha dealer

prior to use.

4. Grease all grease fittings. For further de-

tails, see page 48.

EMU28421

Cleaning and anticorrosion

measures

1. Wash down the exterior of the outboard

motor with fresh water and dry off com-

pletely.

2. Spray the outboard motor exterior with

“Yamaha Silicone Protectant” (Part No.

LUB-SILCNE-13-00).

3. Wax the cowling with a non-abrasive

wax such as “Yamaha Silicone Wax”

(Part No. ACC-11000-15-02).

EMU28430

Battery care

WARNING

EWM00330

Battery electrolytic fluid is dangerous; it

contains sulfuric acid and therefore is

poisonous and highly caustic.

Always follow these preventive mea-

sures:

●

Avoid bodily contact with electrolytic

fluid as it can cause severe burns or

permanent eye injury.

●

Wear protective eye gear when han-

dling or working near batteries.

Antidote (EXTERNAL):

●

SKIN - Flush with water.

●

EYES - Flush with water for 15 minutes

and get immediate medical attention.

Antidote (INTERNAL):

●

Drink large quantities of water or milk

followed by milk of magnesia, beaten

egg, or vegetable oil. Get immediate

medical attention.

Batteries also generate explosive hydro-

gen gas; therefore, you should always

follow these preventive measures:

●

Charge batteries in a well-ventilated ar-

ea.

●

Keep batteries away from fire, sparks,

or open flames (for example: welding

equipment, lighted cigarettes, and so

on.)

●

DO NOT SMOKE when charging or han-

dling batteries.

KEEP BATTERIES AND ELECTROLYTIC

FLUID OUT OF REACH OF CHILDREN.

Batteries vary among manufacturers. There-

fore the following procedures may not al-

ways apply. Consult your battery

manufacturer’s instructions.

Procedure

1. Disconnect and remove the battery from

the boat. Always disconnect the black

negative cable first to prevent the risk of

shorting.

2. Clean the battery casing and terminals.

Fill each cell to the upper level with dis-

1 2 ... 43 44 45 46 47 48 49 50 51 52 53 ... 80 81

Comments to this Manuals

No comments