Yamaha YZF-R1C Owner's Manual Page 1

PRINTED IN JAPAN2001 . 12 - 7.0 × 2 CR(E)PRINTED ON RECYCLED PAPER YAMAHA MOTOR CO., LTD.5PW-28199-10LIT-11626-15-47YZF-R1PYZF-R1PCOWNER’S MANUAL

SAFETY INFORMATION11-24. Many accidents involve inexperienced operators. In fact, many operators who have been involved inaccidents do not even have a

PERIODIC MAINTENANCE AND MINOR REPAIR6-436EAU03497Replacing a turn signal light bulb 1. Remove the turn signal light lensby removing the screw.2. Remo

PERIODIC MAINTENANCE AND MINOR REPAIR6-4462. Remove the socket (together withthe bulb) by pulling it out.3. Remove the defective bulb by pull-ing it o

PERIODIC MAINTENANCE AND MINOR REPAIR6-456EAU04569Front wheel To remove the front wheel EW000122WARNING_ ●It is advisable to have a Yamahadealer servi

PERIODIC MAINTENANCE AND MINOR REPAIR6-466EAU04662To install the front wheel 1. Lift the wheel up between the forklegs.2. Insert the wheel axle.3. Low

PERIODIC MAINTENANCE AND MINOR REPAIR6-476EAU04533Rear wheel To remove the rear wheel EW000122WARNING_ ●It is advisable to have a Yamahadealer service

PERIODIC MAINTENANCE AND MINOR REPAIR6-4867. While supporting the brake caliperbracket, pull the wheel axle out.8. Remove the wheel.ECA00119CAUTION:_

PERIODIC MAINTENANCE AND MINOR REPAIR6-496EAU03087Troubleshooting Although Yamaha motorcycles receivea thorough inspection before shipmentfrom the fac

PERIODIC MAINTENANCE AND MINOR REPAIR6-506EAU02990Troubleshooting charts Starting problems or poor engine performanceEW000125WARNING_ Keep away open f

PERIODIC MAINTENANCE AND MINOR REPAIR6-516Engine overheatingEW000070WARNING_ ●Do not remove the radiator cap when the engine and radiator are hot. Sca

MOTORCYCLE CARE AND STORAGE7Care ... 7-1Storage ...

SAFETY INFORMATION11-3Protective apparelThe majority of fatalities from motorcycle accidents are the result of head injuries. The use of a safetyhelme

7-17EAU045717-MOTORCYCLE CARE AND STORAGECare While the open design of a motorcyclereveals the attractiveness of the tech-nology, it also makes it mor

MOTORCYCLE CARE AND STORAGE7-27●Do not use any harsh chemicalproducts on plastic parts or themuffler. Be sure to avoid usingcloths or sponges which ha

MOTORCYCLE CARE AND STORAGE7-37Cleaning the titanium mufflerThis model is equipped with a titaniummuffler, which requires the followingspecial care.●U

MOTORCYCLE CARE AND STORAGE7-47ECA00013CAUTION:_ ●Apply spray oil and wax spar-ingly and make sure to wipe offany excess.●Never apply oil or wax to an

MOTORCYCLE CARE AND STORAGE7-57a. Remove the spark plug caps andspark plugs.b. Pour a teaspoonful of engine oilinto each spark plug bore.c. Install th

SPECIFICATIONS8Specifications ... 8-1U5PW10.book Page 1 Thursday, J

8-18EAU010388-SPECIFICATIONSSpecifications CS-01EModel YZF-R1/YZF-R1CDimensionsOverall length 2,040 mm (80.3 in)Overall width 705 mm (27.8 in)Overall

SPECIFICATIONS8-28Cooling system capacity (total amount)2.45 L (2.16 lmp qt, 2.59 US qt)Air filter Oil-coated paper elementFuelType PREMIUM UNLEADED G

SPECIFICATIONS8-38Maximum load* YZF-R1: 202 kg (445 lb)YZF-R1C: 201 kg (443 lb)Tire air pressure (measured on cold tires)Up to 90 kg (198 lb)*Front 25

SPECIFICATIONS8-48Bulb voltage, wattage × quantityHeadlight 12 V, 60/55 W × 2Tail/brake light L.E.D.Front turn signal/position light 12 V, 21/5 W × 2R

SAFETY INFORMATION11-4LoadingThe total weight of the operator, passenger, accessories and cargo must not exceed the maximum loadlimit of YZF-R1: 202 k

CONSUMER INFORMATION9Identification numbers ... 9-1Key identification number ...

9-19EAU010399-CONSUMER INFORMATIONEAU02944Identification numbers Record the key identification number,vehicle identification number and mod-el label i

CONSUMER INFORMATION9-29EAU04490Model label The model label is affixed to the frameunder the passenger seat. (See page3-16 for passenger seat removal

CONSUMER INFORMATION9-39EAU01051Reporting safety defects If you believe that your vehicle has a defect which could cause a crash or could cause injury

CONSUMER INFORMATION9-49EAU01053Motorcycle noise regulation TAMPERING WITH NOISE CONTROL SYSTEM PROHIBITED:Federal law prohibits the following acts or

CONSUMER INFORMATION9-59EAU01874Maintenance record Copies of work orders and/or receipts for parts purchased and installed on your motorcycle will be

CONSUMER INFORMATION9-6928,000 mi(43,000 km) or42 months32,000 mi(49,000 km) or48 months36,000 mi(55,000 km) or54 months40,000 mi(61,000 km) or60 mont

CONSUMER INFORMATION9-79EAU02918YAMAHA MOTOR CORPORATION, U.S.A. STREET AND ENDURO MOTORCYCLE LIMITED WARRANTY U5PW10.book Page 7 Thursday, January

CONSUMER INFORMATION9-89U5PW10.book Page 8 Thursday, January 10, 2002 12:15 PM

CONSUMER INFORMATION9-99EAU01063YAMAHA EXTENDED SERVICE (Y.E.S.) U5PW10.book Page 9 Thursday, January 10, 2002 12:15 PM

SAFETY INFORMATION11-5a. Accessories fitted to the handlebar or the front fork area can create instability due to improperweight distribution or aerod

CONSUMER INFORMATION9-109U5PW10.book Page 10 Thursday, January 10, 2002 12:15 PM

INDEXAAccessories and replacement parts ...6-27Air filter element, replacing...6-21BBattery ...

INDEXPParking ... 5-5Part locations... 2-1Pre-operation check

PRINTED IN JAPAN2001 . 12 - 7.0 × 2 CR(E)PRINTED ON RECYCLED PAPER YAMAHA MOTOR CO., LTD.5PW-28199-10LIT-11626-15-47YZF-R1PYZF-R1PCOWNER’S MANUAL

SAFETY INFORMATION11-6a. The engine and exhaust system may be hot, therefore, park the motorcycle in a place where pe-destrians or children are not li

SAFETY INFORMATION11-7EAU02977Location of important labels Please read the following important labels carefully before operating this motorcycle. U5PW

SAFETY INFORMATION11-81 California only6374CAUTIONCleaning with alkaline oracid cleaner, gasoline orsolvent will damagewindshield.Use neutral

SAFETY INFORMATION11-98910U5PW10.book Page 9 Thursday, January 10, 2002 12:15 PM

DESCRIPTION2Left view ... 2-1Right view...

2-12EAU000262-DESCRIPTION Left view1. Fuse box (page 6-40)2. Front fork compression damping force adjusting screw (page 3-19)3. Front fork rebound dam

EAU03438

DESCRIPTION2-22Right view12. Luggage strap holders (page 3-23)13. Helmet holders (page 3-17)14. Main fuse (page 6-40)15. Electronic fuel injection fus

DESCRIPTION2-32Controls and instruments1. Clutch lever (page 3-12)2. Left handlebar switches (page 3-11)3. Multi-function display (page 3-6)4. Main sw

3INSTRUMENT AND CONTROL FUNCTIONSMain switch/steering lock ...3-1Indicator and warning lights ...

3-13EAU000273-INSTRUMENT AND CONTROL FUNCTIONSEAU00029Main switch/steering lock The main switch/steering lock controlsthe ignition and lighting system

INSTRUMENT AND CONTROL FUNCTIONS3-23EW000016WARNING_ Never turn the key to “OFF” or“LOCK” while the motorcycle ismoving, otherwise the electricalsyste

INSTRUMENT AND CONTROL FUNCTIONS3-33EAU04301Oil level warning light “” This warning light comes on when theengine oil level is low.The electrical circ

INSTRUMENT AND CONTROL FUNCTIONS3-43EAU04559Engine speed indicator light The electrical circuit of the indicatorlight can be checked according to thef

INSTRUMENT AND CONTROL FUNCTIONS3-53CB-25ECoolant temperatureDisplay Conditions What to do0–39 °C(0–103 °F)Message “LO” is displayed.OK. Go ahead with

INSTRUMENT AND CONTROL FUNCTIONS3-63EAU04566Multi-function display The multi-function display is equippedwith the following:●a speedometer (which show

INSTRUMENT AND CONTROL FUNCTIONS3-73To reset a tripmeter, select it by push-ing the “SELECT” button, and thenpush the “RESET” button for at leastone s

EAU000021-INTRODUCTIONCongratulations on your purchase of the Yamaha YZF-R1 / YZF-R1C. This model isthe result of Yamaha’s vast experience in the prod

INSTRUMENT AND CONTROL FUNCTIONS3-83Display brightness and enginespeed indicator light control modeThis mode cycles through five controlfunctions, all

INSTRUMENT AND CONTROL FUNCTIONS3-93To adjust the display brightness1. Turn the key to “OFF”.2. Push and hold the “SELECT” but-ton.3. Turn the key to

INSTRUMENT AND CONTROL FUNCTIONS3-103To set the engine speed indicator lightdeactivation functionNOTE:_ ●The indicator light deactivationfunction can

INSTRUMENT AND CONTROL FUNCTIONS3-113EAU00101Tachometer The electric tachometer allows the riderto monitor the engine speed and keep itwithin the idea

INSTRUMENT AND CONTROL FUNCTIONS3-123EAU03890Engine stop switch “ / ” Set this switch to “” before startingthe engine. Set this switch to “” tostop th

INSTRUMENT AND CONTROL FUNCTIONS3-133EAU00161Brake lever The brake lever is located at the righthandlebar grip. To apply the front brake,pull the leve

INSTRUMENT AND CONTROL FUNCTIONS3-143NOTE:_ The fuel tank cap cannot be closed un-less the key is in the lock. In addition,the key cannot be removed i

INSTRUMENT AND CONTROL FUNCTIONS3-153Your Yamaha engine has been de-signed to use regular unleaded gaso-line with a pump octane number[(R+M)/2] of 91

INSTRUMENT AND CONTROL FUNCTIONS3-163To install the rider seatInsert the projection on the front of therider seat into the seat holder asshown, place

INSTRUMENT AND CONTROL FUNCTIONS3-173EAU04489Helmet holders The helmet holders are located on thebottom of the passenger seat.To secure a helmet to a

EAU000031-IMPORTANT MANUAL INFORMATIONParticularly important information is distinguished in this manual by the following notations:The Safety Alert S

INSTRUMENT AND CONTROL FUNCTIONS3-183EAU01862Adjusting the front fork This front fork is equipped with springpreload adjusting bolts, rebound damp-ing

INSTRUMENT AND CONTROL FUNCTIONS3-193Rebound damping forceTo increase the rebound dampingforce and thereby harden the rebounddamping, turn the adjusti

INSTRUMENT AND CONTROL FUNCTIONS3-203EAU04496Adjusting the shock absorber assembly This shock absorber assembly isequipped with a spring preload adjus

INSTRUMENT AND CONTROL FUNCTIONS3-213Rebound damping forceTo increase the rebound dampingforce and thereby harden the rebounddamping, turn the adjusti

INSTRUMENT AND CONTROL FUNCTIONS3-223EAU00315WARNING_ This shock absorber contains high-ly pressurized nitrogen gas. Forproper handling, read and unde

INSTRUMENT AND CONTROL FUNCTIONS3-233EAU03170Luggage strap holders There are four luggage strap holderson the bottom of the passenger seat.To use the

INSTRUMENT AND CONTROL FUNCTIONS3-243EW000044WARNING_ The motorcycle must not be riddenwith the sidestand down, or if thesidestand cannot be properlym

INSTRUMENT AND CONTROL FUNCTIONS3-253CD-01EWith the engine turned off:1. Move the sidestand down.2. Make sure that the engine stop switch is set to “”

PRE-OPERATION CHECKS4Pre-operation check list ... 4-1U5PW10.book Page 1 Thursday,

4-14EAU011144-PRE-OPERATION CHECKSThe condition of a vehicle is the owner’s responsibility. Vital components can start to deteriorate quickly and unex

IMPORTANT MANUAL INFORMATIONEW000000WARNING_ PLEASE READ THIS MANUAL AND THE “YOU AND YOUR MOTORCYCLE: RIDINGTIPS” BOOKLET CAREFULLY AND COMPLETELY BE

PRE-OPERATION CHECKS4-24NOTE:_ Pre-operation checks should be made each time the motorcycle is used. Such an inspection can be accomplished in a verys

OPERATION AND IMPORTANT RIDING POINTS5Starting and warming up a cold engine ... 5-1Shifting ...

5-15EAU003725-OPERATION AND IMPORTANT RIDING POINTSEAU00373WARNING_ ●Become thoroughly familiarwith all operating controls andtheir functions before r

OPERATION AND IMPORTANT RIDING POINTS5-25ECA00132CAUTION:_ The following warning lights and in-dicator light should come on for afew seconds, then go

OPERATION AND IMPORTANT RIDING POINTS5-35EAU00423Shifting Shifting gears lets you control theamount of engine power available forstarting off, acceler

OPERATION AND IMPORTANT RIDING POINTS5-45EAU00427To decelerate 1. Apply both the front and the rearbrakes to slow the motorcycle.2. Shift the transmis

OPERATION AND IMPORTANT RIDING POINTS5-55EAU03172*0–1,000 km (0–600 mi)Avoid prolonged operation above6,000 r/min.1,000–1,600 km (600–1,000 mi)Avoid p

6PERIODIC MAINTENANCE AND MINOR REPAIRPeriodic maintenance ...6-1Owner’s tool kit ...

6-16EAU004626-PERIODIC MAINTENANCE AND MINOR REPAIR EAU01790Safety is an obligation of the owner.Periodic inspection, adjustment and lu-brication will

PERIODIC MAINTENANCE AND MINOR REPAIR6-26NOTE:_ If you do not have the tools or experi-ence required for a particular job, havea Yamaha dealer perform

IMPORTANT MANUAL INFORMATIONAFFIX DEALERLABEL HEREEAU04247YZF-R1P/YZF-R1PCOWNER’S MANUAL©2001 by Yamaha Motor Corporation, U.S.A.1st edition, November

PERIODIC MAINTENANCE AND MINOR REPAIR6-36EAU00471Periodic maintenance chart for the emission control system No. ITEM ROUTINEINITIAL ODOMETER READINGS6

PERIODIC MAINTENANCE AND MINOR REPAIR6-46* Since these items require special tools, data and technical skills, have a Yamaha dealer perform the servic

PERIODIC MAINTENANCE AND MINOR REPAIR6-56EAU00472General maintenance and lubrication chart No. ITEM ROUTINEINITIAL ODOMETER READINGS600 mi (1,000 km)o

PERIODIC MAINTENANCE AND MINOR REPAIR6-669*Rear suspension link pivots• Check operation.• Correct if necessary.√√10*Shock absorber assembly• Check ope

PERIODIC MAINTENANCE AND MINOR REPAIR6-76* Since these items require special tools, data and technical skills, have a Yamaha dealer perform the servic

PERIODIC MAINTENANCE AND MINOR REPAIR6-86EAU01139Removing and installing cowlings and panels The cowlings and panels shown aboveneed to be removed to

PERIODIC MAINTENANCE AND MINOR REPAIR6-96EAU04544Cowling ATo remove the cowling1. Remove the quick fasteners at thefront of the cowling.2. Remove the

PERIODIC MAINTENANCE AND MINOR REPAIR6-106NOTE:_ To install the quick fastener, push thecenter pin out so that it will protrudefrom the fastener head,

PERIODIC MAINTENANCE AND MINOR REPAIR6-116EAU04531Panels A and BTo remove one of the panelsLoosen the quick fastener screws 1/4turn counterclockwise,

PERIODIC MAINTENANCE AND MINOR REPAIR6-126Before installing a spark plug, the sparkplug gap should be measured with awire thickness gauge and, if nece

TABLE OF CONTENTS1 SAFETY INFORMATION12 DESCRIPTION23 INSTRUMENT AND CONTROL FUNCTIONS34 PRE-OPERATION CHECKS45 OPERATION AND IMPORTANT RIDING POINTS5

PERIODIC MAINTENANCE AND MINOR REPAIR6-136EAU00499Canister (for California only) This model is equipped with a canisterto prevent the discharging of f

PERIODIC MAINTENANCE AND MINOR REPAIR6-1462. Start the engine, warm it up forseveral minutes, and then turn it off.3. Wait a few minutes until the oil

PERIODIC MAINTENANCE AND MINOR REPAIR6-1565. Remove the oil filter cartridge withan oil filter wrench.NOTE:_ An oil filter wrench is available at aYam

PERIODIC MAINTENANCE AND MINOR REPAIR6-1669. Add the specified amount of therecommended engine oil, and theninstall and tighten the oil filler cap.ECA

PERIODIC MAINTENANCE AND MINOR REPAIR6-176EAU04298Coolant The coolant level should be checkedbefore each ride. In addition, the cool-ant must be chang

PERIODIC MAINTENANCE AND MINOR REPAIR6-186NOTE:_ ●The radiator fan is automaticallyswitched on or off according to thecoolant temperature in the radia

PERIODIC MAINTENANCE AND MINOR REPAIR6-1968. Remove the coolant drain bolt todrain the cooling system.9. Loosen the radiator hose clampscrew located a

PERIODIC MAINTENANCE AND MINOR REPAIR6-206EC000080CAUTION:_ ●If coolant is not available, usedistilled water or soft tap waterinstead. Do not use hard

PERIODIC MAINTENANCE AND MINOR REPAIR6-216EAU04572*Replacing the air filter element The air filter element should be re-placed at the intervals specif

PERIODIC MAINTENANCE AND MINOR REPAIR6-2266. Pull the air filter element out.7. Insert a new air filter element intothe air filter case.EC000082*CAUTI

SAFETY INFORMATION1Safe riding ... 1-1Protective apparel ...

PERIODIC MAINTENANCE AND MINOR REPAIR6-236EWA00067WARNING_ ●Before installing the fuel tank,make sure that the fuel hosesare not damaged. If any fuelh

PERIODIC MAINTENANCE AND MINOR REPAIR6-246EAU03581Tires To maximize the performance, durabil-ity, and safe operation of your motor-cycle, note the fol

PERIODIC MAINTENANCE AND MINOR REPAIR6-256Tire inspectionAlways check the tires before operatingthe motorcycle. If a tire tread showscrosswise lines (

PERIODIC MAINTENANCE AND MINOR REPAIR6-266EW000080WARNING_ ●The front and rear tires shouldbe of the same make and de-sign, otherwise the handlingchar

PERIODIC MAINTENANCE AND MINOR REPAIR6-276EAU03773Cast wheels To maximize the performance, durabil-ity, and safe operation of your motor-cycle, note t

PERIODIC MAINTENANCE AND MINOR REPAIR6-286EAU01356Adjusting the clutch lever free play The clutch lever free play should mea-sure 10–15 mm (0.4–0.6 in

PERIODIC MAINTENANCE AND MINOR REPAIR6-296EAU01357Adjusting the brake pedal position The top of the brake pedal should bepositioned approximately 38–4

PERIODIC MAINTENANCE AND MINOR REPAIR6-306EAU00721Checking the front and rear brake pads The front and rear brake pads must bechecked for wear at the

PERIODIC MAINTENANCE AND MINOR REPAIR6-3162. Install the brake caliper bolt, andthen tighten it to the specifiedtorque.EAU03294Checking the brake flui

PERIODIC MAINTENANCE AND MINOR REPAIR6-326●Be careful that water does not en-ter the brake fluid reservoir whenrefilling. Water will significantlylowe

11-1EAU041931-SAFETY INFORMATIONMOTORCYCLES ARE SINGLE TRACK VEHICLES. THEIR SAFE USE AND OPERATION ARE DE-PENDENT UPON THE USE OF PROPER RIDING TECHN

PERIODIC MAINTENANCE AND MINOR REPAIR6-336EAU00744Drive chain slack The drive chain slack should bechecked before each ride and adjustedif necessary.T

PERIODIC MAINTENANCE AND MINOR REPAIR6-346NOTE:_ Using the alignment marks on eachside of the swingarm, make sure thatboth chain pullers are in the sa

PERIODIC MAINTENANCE AND MINOR REPAIR6-356EAU03297Checking and lubricating the cables The operation of all control cables andthe condition of the cabl

PERIODIC MAINTENANCE AND MINOR REPAIR6-366EAU03163Lubricating the brake pedal The operation of the brake pedalshould be checked before each ride,and t

PERIODIC MAINTENANCE AND MINOR REPAIR6-376EAU02939Checking the front fork The condition and operation of the frontfork must be checked as follows at t

PERIODIC MAINTENANCE AND MINOR REPAIR6-3862. Hold the lower ends of the frontfork legs and try to move them for-ward and backward. If any freeplay can

PERIODIC MAINTENANCE AND MINOR REPAIR6-396EAU01291Battery This motorcycle is equipped with asealed-type (MF) battery, which doesnot require any mainte

PERIODIC MAINTENANCE AND MINOR REPAIR6-406EC000102CAUTION:_ ●Always keep the batterycharged. Storing a dischargedbattery can cause permanentbattery da

PERIODIC MAINTENANCE AND MINOR REPAIR6-416EC000103CAUTION:_ Do not use a fuse of a higher amper-age rating than recommended toavoid causing extensive

PERIODIC MAINTENANCE AND MINOR REPAIR6-426EW000119WARNING_ Headlight bulbs get very hot. There-fore, keep flammable products awayfrom a lit headlight